1、兩臺發電機組并機使用的條件是什么？用什么裝置來完成并機工作？
1. What are the conditions for the parallel operation of two generator sets? What device is used to complete the parallel operation?
答：并機使用的條件是兩臺機瞬間的電壓、頻率、相位相同。俗稱“三同時”。用專用并機裝置來完成并機工作。一般建議采用全自動并機柜。盡量不用手動并機。因為手動并機的成功或失敗取決于人為經驗。筆者以20多年從事電力工作的經驗斗膽放言，柴油發電機手動并機的可靠成功率等于0。決不能以市電大電源系統可用手動并機的概念來套用小電源系統，因為二者的保護等級完全不一樣的。
Answer: the condition for parallel operation is that the voltage, frequency and phase of the two machines are the same at the moment. Commonly known as "three Simultaneities". Use special paralleling device to complete paralleling work. It is generally recommended to adopt fully automatic parallel cabinet. Try not to parallelize manually. Because the success or failure of manual paralleling depends on human experience. Based on more than 20 years of experience in power work, the author ventured to say that the reliable success rate of manual paralleling of diesel generators is equal to 0. We must not apply the concept of manual paralleling to the small power supply system, because the protection level of the two is completely different.
2、三相發電機的功率因數是多少？為提高功率因素可以加功率補償器嗎？
2. What is the power factor of a three-phase generator? Can a power compensator be added to improve the power factor?
答：功率因素為0.8。不可以，因為電容器的充放電會導致小電源的波動。及機組振蕩。
Answer: the power factor is 0.8. No, because the charging and discharging of capacitors will cause small power supply fluctuations. And unit oscillation.
3、為什么我們要求客戶，機組每運行200小時后，要進行一項所有電器接觸件的緊固工作？答：柴油發電機組屬振動工作器。而且很多國內生產或組裝的機組該用雙螺母的沒用。該用彈簧墊片的沒用，一旦電器緊固件松懈，會產生很大的接觸電阻，導致機組運行不正常。
3. Why do we require our customers to tighten all electrical contacts every 200 hours of operation? Answer: the diesel generator set is a vibration device. And many domestic production or assembly units that should use double nuts are useless. It's useless to use spring gaskets. Once the electrical fasteners are loosened, a large contact resistance will be generated, resulting in abnormal operation of the unit.
4、為什么發電機房保證清潔、地面無浮沙？
4. Why is the generator room clean and the ground free of floating sand?
答：柴油機若吸入臟空氣會使功率下降；發電機若吸入沙粒等雜質會使定轉子間隙之間的絕緣破壞，重者導致燒毀。
Answer: if the diesel engine inhales dirty air, its power will decrease; If the generator inhales sand and other impurities, the insulation between the stator and rotor gaps will be damaged, which will lead to burning.
5、為什么自2002年開始我公司一般不建議用戶在安裝時采用中性點接地？
5. Why does our company generally not recommend that users adopt neutral grounding during installation since 2002?
答：1）新一代發電機自我調節功能大大增強；2）實踐中發現中性點接地機組的雷電故障率偏高；3）接地質量要求較高、一般用戶無法辦到。不安全的工作接地不如不接地；4）中性點接地的機組會掩蓋負荷的漏電故障及接地錯誤，而這些故障和錯誤在市電大電流供電情況下無法暴露。
Answer: 1) the self-regulation function of the new generation generator is greatly enhanced; 2) In practice, it is found that the lightning fault rate of neutral grounded units is high; 3) The requirements for grounding quality are high, which is impossible for ordinary users. It is better not to be grounded for unsafe work; 4) The neutral grounded unit will cover up the leakage fault and grounding error of the load, which cannot be exposed under the condition of large current supply of the municipal power supply.
The above is the detailed introduction of the alloy tail gas generator set introduced to you. I hope it can help you. If you have any questions, please contact us. We will provide services for you with a professional attitude http://www.inyanfang.cn
全國服務熱線:
濟南濟柴環能燃?xì)獍l(fā)電設備有限公司
